OP
Wed, 18 May 2022 11:34:06 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Wed, 18 May 2022 11:34:06 +0000 quote
Having starting problems on my Vespa 300gts (2014, 16k km). Serviced regularly, by myself, driven shorter distances most of the days.
The scooter usually starts on a first start, but after a first drive (and a quick stop) there is trouble cranking. Sometimes it just thud and nothing, sometimes it is like a jarring clunk after I press start. I wait – sometimes for a few minutes, try again, and it starts. Sometimes I have to wait for like 5 minutes.
I spent hours diagnosing and jumping through hoops:
- Lights are up on key turn, break lights operate, on/off switch is ok. Fuel pump primes, dash lights up.
- Battery less than 1y old. Holds current 12.7, goes down first then up to 13.0 on start, on revs - 13.6. Honestly the same symptoms were present on the old battery.
- Checked for all the electrical issues (as per robots video). All normal readings. Battery charges ok. (did not check regulator/ too deep).
- Starter relay replaced to a new one. Again current to relay equals to that of the battery.
- Continuity checked battery->relay, relay-> starter, starter->battery, all ok.
- Starter removed and checked on external battery – it spins, with a large spark though. -
Cant tell if anything is abnormal. Put back into the scooter – symptoms are the same.
- Checked for parasitic current draw (pulling fuses, Amp reading) – nothing unusual detected.
- There is a short somewhere in the steering wheel cabling (clock resets occasionally when turned to the left, with a buzzing sound). It has been like that for years tho.

The only thing I seem to have left – sprag clutch? weak starter?

starting video here:
Thanks for your help
xS
Wed, 18 May 2022 12:13:09 +0000

Veni, Vidi, Posti
Neutrino MP3 492.7 AK, 2013 Moto Guzzi Norge
Joined: Sun, 30 Mar 2008 04:38:24 +0000
Posts: 22144
Location: Harriman, Tennessee, Tn
 
Veni, Vidi, Posti
Neutrino MP3 492.7 AK, 2013 Moto Guzzi Norge
Joined: Sun, 30 Mar 2008 04:38:24 +0000
Posts: 22144
Location: Harriman, Tennessee, Tn
Wed, 18 May 2022 12:13:09 +0000 quote
sounds like the valves might be tight.
OP
Wed, 18 May 2022 14:35:23 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Wed, 18 May 2022 14:35:23 +0000 quote
old as dirt wrote:
sounds like the valves might be tight.
valves adjusted 5 months ago (intake = ok; exhaust both slightly tight = 1/4 turn to loosen both)
Wed, 18 May 2022 20:49:05 +0000

Veni, Vidi, Posti
Neutrino MP3 492.7 AK, 2013 Moto Guzzi Norge
Joined: Sun, 30 Mar 2008 04:38:24 +0000
Posts: 22144
Location: Harriman, Tennessee, Tn
 
Veni, Vidi, Posti
Neutrino MP3 492.7 AK, 2013 Moto Guzzi Norge
Joined: Sun, 30 Mar 2008 04:38:24 +0000
Posts: 22144
Location: Harriman, Tennessee, Tn
Wed, 18 May 2022 20:49:05 +0000 quote
keltis99 wrote:
valves adjusted 5 months ago (intake = ok; exhaust both slightly tight = 1/4 turn to loosen both)
the lock nuts could have backed off , seen this before.
Wed, 18 May 2022 23:38:44 +0000

Addicted
2022 Honda PCX 150A, 2018 GTS300 [sold] & 2015 GTS300 Super [sold]
Joined: Wed, 27 Sep 2017 01:21:34 +0000
Posts: 843
Location: Connecticut, USA
 
Addicted
2022 Honda PCX 150A, 2018 GTS300 [sold] & 2015 GTS300 Super [sold]
Joined: Wed, 27 Sep 2017 01:21:34 +0000
Posts: 843
Location: Connecticut, USA
Wed, 18 May 2022 23:38:44 +0000 quote
ECU/throttle body??? Next time it happens, give it the ole Throttle Body Tap and see if it starts.

OP
Wed, 25 May 2022 10:18:53 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Wed, 25 May 2022 10:18:53 +0000 quote
Here is another video showcasing the starting problem of my 300gts (stuck on the 2nd try at 0.40sec - which is the usual scenario of my reoccurring problems). Got stuck in the city today after a few short runs…jumping the battery helped to start it again but just barely...

Can it really be the battery just after 1 year? I have yuasa YTX12-BS 12V/10AH

Wed, 25 May 2022 15:28:18 +0000

Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
 
Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
Wed, 25 May 2022 15:28:18 +0000 quote
Do you occasionally fully charge the battery with a charger or maintainer? Unless the battery can get a decent bulk charge at 14.4V or thereabouts once in a while it will gradually lose capacity and sulphate.

I have seen several batteries die within a year, usually because of lots of short journeys without them ever getting back to full charge.
OP
Wed, 25 May 2022 16:01:08 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Wed, 25 May 2022 16:01:08 +0000 quote
I use CX trickle charger once a month and now more often....so yes it gets a boost certainly
Wed, 25 May 2022 16:46:38 +0000

Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
 
Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
Wed, 25 May 2022 16:46:38 +0000 quote
keltis99 wrote:
I use CX trickle charger once a month and now more often....so yes it gets a boost certainly
Can you give more details on this charger? Google reveals nothing. I do know that some so-called trickle chargers just don't do anywhere near a decent job of fully charging a battery. They're fine for keeping a fully charged battery happy, not for fully charging it in the first place.
OP
Thu, 26 May 2022 07:08:05 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Thu, 26 May 2022 07:08:05 +0000 quote
sorry its is ctek mxs 5.0 trickle charger. quite a popular choice - had it for years and used successfully on many other bikes/vehicles.
OP
Thu, 26 May 2022 07:22:09 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Thu, 26 May 2022 07:22:09 +0000 quote
my own impression of the problem is that:
a) the battery is not good (does not have enough cranking power) - buy new battery?
b) or something with the sprag clutch (mechanical damage?)/starter motor (needs cleaning?) - open of the water pump side/new starter motor etc.
Thu, 26 May 2022 15:14:04 +0000

Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
 
Moderaptor
The Hornet (GT200, aka Love Bug) and 'Dimples' - a GTS 300
Joined: Sun, 26 Aug 2007 20:16:15 +0000
Posts: 41938
Location: Pleasant Hill, CA
Thu, 26 May 2022 15:14:04 +0000 quote
keltis99 wrote:
sorry its is ctek mxs 5.0 trickle charger. quite a popular choice - had it for years and used successfully on many other bikes/vehicles.
That's fine.
keltis99 wrote:
my own impression of the problem is that:
a) the battery is not good (does not have enough cranking power) - buy new battery?
Cheapest and easiest test and solution.
Quote:
b) or something with the sprag clutch (mechanical damage?)/starter motor (needs cleaning?) - open of the water pump side/new starter motor etc.
The sprag clutch playing up would probably make much more of a grinding noise (I've had two go on me!) so a last resort IMHO.
OP
Sun, 05 Jun 2022 16:35:11 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Sun, 05 Jun 2022 16:35:11 +0000 quote
Thanks Jimc. So after thinking it over I decided to open the crank case side and inspect the (sprag) clutch mechanism. Main reason: after being parked on the side stand my vespa had many more starting issues than when the central stand was used and I suspect a mechanical cause – a clutch wheel not sliding back into correct position etc.

After opening I noticed that both the smaller and larger clutch wheels had quite a bit of play (I would say ~5mm forth and back on the shaft). Again – sometimes vespa started, sometimes not (with some grinding noise). Battery was always at 12.7v and I am quite confident its not electrical related. Any suggestion if they are (smaller or larger wheel – parts nr. 4 & 5) on the way out based on my videos?

https://youtube.com/shorts/mdH5u5EkKBE?feature=share

https://youtube.com/shorts/3JCrzbSOYcg?feature=share



OP
Sun, 05 Jun 2022 16:35:58 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Sun, 05 Jun 2022 16:53:35 +0000

Hooked
2020 primavera 150
Joined: Sat, 08 Aug 2020 22:05:49 +0000
Posts: 423
Location: Lorton virginia
 
Hooked
2020 primavera 150
Joined: Sat, 08 Aug 2020 22:05:49 +0000
Posts: 423
Location: Lorton virginia
Sun, 05 Jun 2022 16:53:35 +0000 quote
It still sounds like a bad battery
Mon, 06 Jun 2022 10:44:10 +0000

Addicted
2022 Honda PCX 150A, 2018 GTS300 [sold] & 2015 GTS300 Super [sold]
Joined: Wed, 27 Sep 2017 01:21:34 +0000
Posts: 843
Location: Connecticut, USA
 
Addicted
2022 Honda PCX 150A, 2018 GTS300 [sold] & 2015 GTS300 Super [sold]
Joined: Wed, 27 Sep 2017 01:21:34 +0000
Posts: 843
Location: Connecticut, USA
Mon, 06 Jun 2022 10:44:10 +0000 quote
Did you give the throttle body/ECU a light tap (see video above)? That's what mine sounded like until I replaced the throttle body/ECU assembly. It sounded like it was turning over (and going to start), but it just never had the "oomph" to do so.
OP
Mon, 06 Jun 2022 11:35:55 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Mon, 06 Jun 2022 11:35:55 +0000 quote
yes i have - many times. does not help.

After yesterday's venture into the crankcase now the Vespa does not start. only the whirling sound from the starter (which I also rebuilt and cleaned). Symptoms are the same as in this post: 300GTS Not starting (Page 2) Maybe the clutch did not like my WD40 action?

So pretty much i made peace with the sprag clutch-proper mechanic required situation. Will keep you posted.
theschuman wrote:
Did you give the throttle body/ECU a light tap (see video above)? That's what mine sounded like until I replaced the throttle body/ECU assembly. It sounded like it was turning over (and going to start), but it just never had the "oomph" to do so.
OP
Mon, 06 Jun 2022 14:27:26 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Mon, 06 Jun 2022 14:27:26 +0000 quote
Harry brenner wrote:
It still sounds like a bad battery
tested it with a different and more powerful battery - same issue.
OP
Wed, 22 Jun 2022 12:10:30 +0000

Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
 
OP
Enthusiast
GTS 300 super (US v.)
Joined: Fri, 03 Jan 2014 13:57:42 +0000
Posts: 72
Location: Brussels, Belgium
Wed, 22 Jun 2022 12:10:30 +0000 quote
so the end of the story - it was a problem in the flywheel/rotor assembly (sprag?). the mechanic fixed it replacing the whole part (nr: 1A016720)
he explained that the circular ring attached to the rotor/flywheel had these pins that need to eject to get traction from the starter wheel - one of the pins was jammed inside its placeholder (circled). Since the rotor/flywheel comes in one piece the whole thing had to be replaced (at a hefty price.)...he said the part was updated in the newer Vespas and apparently rebuilding should be more of an option from now on. Mechanic could not give me a definitive answer why the part failed (not a very common failure).
so yes, anything with a starter clutch is expensive (just shy of 400e)...at least i have a fine running Vespa now



Wed, 22 Jun 2022 12:54:10 +0000

Ossessionato
GTS 300ie Touring 2013 - Signora D'argento & GTS 300ie HPE 2022 - Regina Arancione.
Joined: Sun, 03 Jun 2018 08:14:34 +0000
Posts: 2047
Location: Lancaster, U.K.
 
Ossessionato
GTS 300ie Touring 2013 - Signora D'argento & GTS 300ie HPE 2022 - Regina Arancione.
Joined: Sun, 03 Jun 2018 08:14:34 +0000
Posts: 2047
Location: Lancaster, U.K.
Wed, 22 Jun 2022 12:54:10 +0000 quote
I'm glad you have a successful outcome. It sounds like you have a great mechanic to be able to diagnose and remedy the fault. It might be an idea to amend your post title by adding 'SOLVED', like I did with my recent post from yesterday.
  DoubleGood Design  

Modern Vespa is the premier site for modern Vespa and Piaggio scooters. Vespa GTS300, GTS250, GTV, GT200, LX150, LXS, ET4, ET2, MP3, Fuoco, Elettrica and more.


Shop on Amazon with Modern Vespa

Modern Vespa is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to amazon.com

All Content Copyright 2005-2023 by Modern Vespa. All Rights Reserved.

[ Time: 0.0591s ][ Queries: 8 (0.0290s) ][ Debug on ][ 276 ][ Thing Two ]